Vestil BBL-OC-4 handleiding
Handleiding
Je bekijkt pagina 3 van 6
TABLE OF CONTENTS Rev. 7/6/2021 BBL-OC-4 MANUAL
TABLE OF CONTENTS Copyright 2021 Vestil Manufacturing Co. Page 3 of 6
NATIONAL STANDARDS
US OSHA Rule 1910.178 (29 CFR 1910.178; the “Rule”) classifies this device as a front end attachment
whenever it is mounted on the forks of a lift truck. The Rule incorporates American National Standard
ANSI/ITSDF B56.1 (the “Standard”). The Standard is published by the Industrial Truck Standards
Development Foundation on its website where it is freely downloadable at
http://www.itsdf.org/cue/b56-standards.html
. Before putting this device into service, you must acquire a
copy of the Standard. Apply all relevant parts of Part II: For the User. If instructions provided in this
manual conflict with the Standard, then apply the instructions in the Standard. Vestil requests that you
immediately bring such conflicts to the attention of its
TECHNICAL SERVICE personnel. Contact
information for TECHNICAL SERVICE appears on the cover page of this manual.
SIGNAL WORDS
This manual uses SIGNAL WORDS to indicate the likelihood of personal injuries, as well as the probable
seriousness of those injuries, if the product is misused in the ways described. Other signal words call
attention to uses of the product likely cause property damage. The following are signal words used in
this manual and their definitions.
SAFETY INSTRUCTIONS
Vestil strives to identify foreseeable hazards associated with the use of its products. However, no
manual can address every conceivable risk. The most effective way to avoid injury is to exercise sound
judgment when assembling, using, inspecting, and maintaining this crane.
WARNING
Risks of serious personal injuries or death.
• Read this manual in its entirety before installing, using or servicing the product. Read the manual to
refresh your understanding of use, inspection, and maintenance procedures as necessary. A copy of
this manual should always be available to all persons who use, inspect and/or maintain this device.
• Review the safety messages included on labeling, and in the manuals, of devices used with this bulk
bag lifter, e.g. bulk bag and forklift.
• Inspect & maintain the lifter as instructed in the INSPECTIONS & MAINTENANCE section on p. 4. Do not
use the lifter unless it is in SATISFACTORY CONDITION. See RECORD OF SATISFACTORY CONDITION, p. 4.
• DO NOT remove or obscure any label. Before using the lifter, confirm that all labels are in place and
easily readable from a reasonable distance. See LABELING DIAGRAM on p. 5.
• DO NOT allow people to ride in the bulk bag or on the lifter.
• DO NOT lift more than the capacity/rated load of this lifter or the bulk bag, whichever is smaller. The
capacity of the lifter is 4,000 pounds (1818.2 kg). The capacity of Vestil’s FAB-H bulk bag is 3,300 pounds
(1500kg). If this lifter is used to lift and move FAB-H bags, do not lift more than 3,300 pounds.
• Before mounting a bulk bag on the lifter, inspect the bulk bag handles and the bag. Confirm that all
parts are in good condition. DO NOT use the lifter to support or transport a bag UNLESS the handles and
bag are undamaged.
• DO NOT lift or travel with a load elevated more than necessary to avoid contact with the ground. Bag
contents might shift during transport so travel slowly. Avoid sudden stops to minimize load swing. Turn
slowly and carefully. Make sure that the travel path is clear of persons and obstacles before transporting
a bulk bag with this lifter.
• Use this product consistently with both the relevant portions of the current revision of ANSI/ITSDF B56.1
and your lift truck operator training.
• DO NOT pull or drag loads with the lifter. ONLY use the lifter to lift and transport bulk bags.
• DO NOT leave a suspended load unattended. Always land the load before leaving it unattended.
DANGER
Identifies a hazardous situation which, if not avoided, WILL result in DEATH or
SERIOUS INJURY. Use of this signal word is limited to the most extreme situations.
WARNING
Identifies a hazardous situation which, if not avoided, COULD result in DEATH or
SERIOUS INJURY.
CAUTION
Indicates a hazardous situation which, if not avoided, COULD result in MINOR or
MODERATE injury.
NOTICE
Identifies practices likely to result in product/property damage, such as
operation that might damage the product.
!
!
!
!
Bekijk gratis de handleiding van Vestil BBL-OC-4, stel vragen en lees de antwoorden op veelvoorkomende problemen, of gebruik onze assistent om sneller informatie in de handleiding te vinden of uitleg te krijgen over specifieke functies.
Productinformatie
| Merk | Vestil |
| Model | BBL-OC-4 |
| Categorie | Niet gecategoriseerd |
| Taal | Nederlands |
| Grootte | 1519 MB |
