Hazet 2588-1/4 handleiding
Handleiding
Je bekijkt pagina 6 van 16
HAZET-WERK
4480
2/4
These VW group 1.2TFSI engines were first introduced in 2010 and
are available in vehicles across the four brands.
These four cylinder engines have a single camshaft, with two valves
per cylinder. A timing chain is used to connect drive between the
crankshaft and camshaft. These engines are turbo charged and use a
high pressure direct injection fuel system.
Timing Check
The threaded hole for the crankshaft locking pin is located at the rear
of the engine block, and towards the timing chain cover.
Remove the blanking plug from the engine.
Install HAZET 2588-21 crankshaft locking pin and tighten to 30Nm.
NOTE: If it is not possible to fully screw in HAZET 2588-21 pin,
then remove the pin and rotate the crankshaft pulley 90 degrees in the
direction of engine rotation and then refit HAZET 2588-21 crankshaft
locking pin.
Carefully rotate the crankshaft pulley in the direction of engine rotation
until the web of the crankshaft contacts HAZET 2588-21 crankshaft
locking pin.
The engine is shown with the sump removed for clarity
Introduction
The camshaft locking tool locates into the cylinder head at gearbox
end.
Remove engine components to give access.
Examine the camshaft position relative to the cylinder head. The
position should appear as in picture 3.
Install HAZET 2588-20 camshaft locking tool and secure in place with
a suitable bolt.
If it is not possible to correctly install HAZET 2588-20 camshaft
locking tool then the engine timing requires adjustment.
When correct valve timing has been established, refer to section
“Refitting timing cover” on page 4 for important information on the
correct assembly procedure.
2588-1/4
1
2
3
4
Bekijk gratis de handleiding van Hazet 2588-1/4, stel vragen en lees de antwoorden op veelvoorkomende problemen, of gebruik onze assistent om sneller informatie in de handleiding te vinden of uitleg te krijgen over specifieke functies.
Productinformatie
| Merk | Hazet |
| Model | 2588-1/4 |
| Categorie | Niet gecategoriseerd |
| Taal | Nederlands |
| Grootte | 11300 MB |
