Vestil HLD-116-10-P-DC handleiding
Handleiding
Je bekijkt pagina 3 van 19
Table of Contents 2/4/2022 HLD MANUAL
Table of Contents Copyright 2010 Vestil Manufacturing Corp. Page 3 of 19
SIGNAL WORDS
This manual uses SIGNAL WORDS to indicate the likelihood of personal injuries, as well as the probable
seriousness of those injuries, if the product is misused in the ways described. Other signal words call
attention to uses of the product likely to cause property damage. The following are signal words used in
this manual and their definitions.
SAFETY INSTRUCTIONS
Vestil strives to identify all hazards associated with the use of our products. However, material
handling is dangerous and no manual can address every risk. The most effective way to avoid injury is
for the end-user to exercise sound judgment whenever using this product.
DANGER
Electrocution might result if any part of the dumper contacts electrified wires.
DO NOT contact electrified wires with any part of the dumper or an applied load.
DO NOT install or use the HLD in an area where contact with electrified wires might occur.
Always inspect the usage area for unusual conditions that require special precautions before
operating the dumper.
Improper or careless operation could result in serious personal injuries or death.
• ONLY use the drum dumper as a means for emptying appropriately sized drums. See OPERATING THE
DRUM DUMPER on p. 5.
• DO NOT use a damaged dumper. Inspect the dumper as instructed the INSPECTIONS section of this
manual on p. 6. DO NOT use the HLD unless it is in SATISFACOTRY CONDITION. See RECORD OF
SATISFACTORY CONDITION on p. 4.
• DO NOT stand beneath or travel under the dumper chute while it is elevated or allow others to do so.
• DO NOT lift people with the chute or allow people to ride on the chute.
• DO NOT use UNLESS all labels shown in the LABELING DIAGRAM on p. 18 are in place, undamaged,
and easily readable.
• DO NOT exceed the maximum rated load of the dumper. The weight of the drum to be dumped plus
the weight of its contents must not exceed the maximum rated load.
• DO NOT modify the box dumper in any way UNLESS you first obtain express, written approval from
Vestil. Unapproved modifications might make the dumper unsafe to use, and could result in operator
and/or bystander injury.
• Avoid contact with the drum chute and loads applied to the chute. This drum chute that elevates
and pivots. Stand to the side of the dumper and watch the chute carefully while operating the
dumper.
• DO NOT operate dumper unless BOTH drum clamps securely engage the drum rim. See Figures 2A
and 2B on p. 5
• DO NOT the dumper unattended if the chute is elevated and/or tilted. Immediately after dumping a
drum, return the chute to the home position and remove dumped drum from the chute.
• DO NOT modify this product in any way. Modifications automatically void the LIMITED WARRANTY and
might make the table unsafe to use
• Instruct all people to clear the area around the dumper BEFORE operating it.
• DO NOT load or operate the dumper UNLESS it is either securely attached to floor (HLD-##-##-S
models) or both floor locks are applied (HLD-##-##-P models).
DANGER
Identifies a hazardous situation which, if not avoided, WILL result in DEATH or
SERIOUS INJURY. Use of this signal word is limited to the most extreme situations.
WARNING
Identifies a hazardous situation which, if not avoided, COULD result in DEATH or
SERIOUS INJURY.
CAUTION
Indicates a hazardous situation which, if not avoided, COULD result in MINOR or
MODERATE injury.
NOTICE
Identifies practices likely to result in product/property damage, such as
operation that might damage the product.
!
!
!
WARNING
!
!
Bekijk gratis de handleiding van Vestil HLD-116-10-P-DC, stel vragen en lees de antwoorden op veelvoorkomende problemen, of gebruik onze assistent om sneller informatie in de handleiding te vinden of uitleg te krijgen over specifieke functies.
Productinformatie
| Merk | Vestil |
| Model | HLD-116-10-P-DC |
| Categorie | Niet gecategoriseerd |
| Taal | Nederlands |
| Grootte | 5109 MB |
