Vestil EPT-2547-30 handleiding
Handleiding
Je bekijkt pagina 23 van 58
TABLE OF CONTENTS 5/19/2022 EPT MANUAL
TABLE OF CONTENTS Copyright 2021 Vestil Manufacturing Page 23 of 58
TROUBLESHOOTING
Before performing any corrective action described in the following table, block the drive
wheel off of the ground.
Contact Vestil for problems at time of installation, or for any problems not addressed below.
ISSUE
CAUSE
REMEDY
Unit does not respond to
movement controls (does not
move either forward or in
reverse).
Battery voltage low (battery
charge lower than 17 Volts)
Problem with motor controller
(check for LED flash code on
side of controller)
Fuse blown
Charge batteries.
Consult diagnostics page/factory
Remove back shroud and check
fuses (3 fuses).
Unit will not charge
Charger malfunction
Bad batteries
Verify output voltage on charger,
will only get a reading when
connected to batteries; should be
approximately 28 volts.
Load test the batteries
Unit will not go forward; reverse
works; belly switch just kills unit
(does not go forward and time
out)
Broken wire, or loose connection
Contactor bad, motor controller
bad
Locate Pin 2 on Molex connector
at motor controller. Trace wiring
to contactor and verify
connection.
When forward is depressed,
there should be 24 volts on this
wire from Molex connector to the
contactor, if not, the motor
controller may be bad; consult
diagnostics page/factory. If 24
volts is present at contactor,
verify ground connection. If
ground is good, remove both
wires and check with ohm meter;
resistance should be
approximately 38 ohms. If it’s
open or zero, the contactor
should be replaced.
Unit will not go reverse; belly
switch works (i.e. when the
handle is in operating range and
rotating throttle in reverse and
the belly switch is hit, the unit
moves forward and times out)
Broken wire, or loose connection,
contactor bad, motor controller
bad
Same as above; except locate
Pin 3 on Molex connector on
motor controller…and follow
procedure.
Bekijk gratis de handleiding van Vestil EPT-2547-30, stel vragen en lees de antwoorden op veelvoorkomende problemen, of gebruik onze assistent om sneller informatie in de handleiding te vinden of uitleg te krijgen over specifieke functies.
Productinformatie
| Merk | Vestil |
| Model | EPT-2547-30 |
| Categorie | Vorkheftruck |
| Taal | Nederlands |
| Grootte | 48560 MB |
