Silverline 571429 handleiding

Handleiding

123456789101112131415161718192021222324252627282930313233343536373839404142434445464748/ 48

Afdrukken

Je bekijkt pagina 7 van 48

Auto-Locking Oval Karabiner571429

7

silverlinetools.com

Proper alignment of the karabiner under load

• The karabiner must be installed so that the loads are applied in the area designed for greatest

strength (see marking on the product and Fig. B)

• The anchorage or anchorage connector should be seated in the radius of the karabiner opposite

the Gate (4)

• DONOTapplyloadsacrosstheGate

• Thekarabinermustbeabletomovefreelyandwithoutinterferenceduringuse.ANYconstraintor

external pressure is DANGEROUS

• Beawarethatsomeequipmentcombinationsmayreducetheeffectivestrengthofthekarabiner

(e.g. when connecting to wide straps)

Note: Regularlycheckconnectionswithotherequipmentinthesystemduringuse,andensure

varioussystemcomponentsarecorrectlypositionedwithrespecttoeachother.Thismaysave

yourlife!

Rescue plan

WARNING:Asuitableandsufcientriskassessmentmustbecarriedoutbeforecommencing

withanykindofworkatheight,oranyworkthatrequirestheuseofpersonalprotectiveequipment

(PPE)asacontrolmeasure.

• The user must have a rescue plan and the means at hand to implement it

• Theplanmusttakeintoaccounttheequipmentandspecialtrainingnecessarytoeffectively

conduct prompt rescue under all foreseeable conditions

Accessories

• Additional fall arrest equipment, workwear and other personal protection equipment is available

fromyourSilverlinestockist

Maintenance

Note: Allfallarrestequipmentmustberegularlyinspected,cleanedandmaintainedbya

competent person, in accordance with local laws and regulations. Maintenance must be recorded in

a dedicated service record (see end of this manual).

WARNING:Carryoutavisualandtactileinspectionofallcomponents,everytimethe

equipmentisused.Carryoutadetailedexaminationiftheequipmenthasnotbeenusedforsome

time. Note: A thorough, detailed examination of the equipment must be carried out at regular

intervals,atleastonceannually,ormorefrequentlydependingonuse.

WARNING:ItisILLEGALtocarryoutanykindofrepairormodicationtofallarrestequipment.

WARNING:Shouldanydamagebedetected,removetheequipmentfromserviceimmediately.

Itmustthenberenderedunusableanddiscarded.

Inspection procedure

• Thefollowingprocedurehelpsdetectdefectspotentiallyresultingindegradationand/or

weakening of karabiners:

1. Inspectformissingoralteredparts.Refertotheimagein‘ProductFamiliarisation’for

identication.Verifyeachitemispresentandhasnotbeentamperedwith

2. Inspecttheentirekarabinerforcracks,nicksorbreaksinthemetal.Inspecteverymillimetre

Note: Ifnecessary,cleanbeforeinspection,tobeabletodetectevensmallhairlinecracks.

3. Inspectfordeformation,bentsordentedparts.OpentheGateandinspecttheNose(1)ofthe

karabiner for signs of wear, distortion or damage

4. Inspectthemetalsurfaceforanysignsofcorrosion.Steelkarabinersmayshowreddustas

evidenceofcorrosion,aluminiumkarabinersmaydeveloppittingorscales

5. Inspectforheatdamage,whichcanusuallybeseenasdiscolorationordarkeningofthemetal

surfaces

6. Performafunctionaltest:TheLockingSleevemustrotateeasily,andthekarabinermustfully

openandclosesmoothlyandeasily.Whenlocked,theGateMUSTNOTopenunderpressurefrom

anydirection

• Inspectallothercomponentsorsubsystemofthefallarrestequipmentaccordingto

manufacturer's instructions

• Record inspection date and results in a dedicated service record (see end of this manual)

Note:Referto‘Servicelifeandproductobsolescence’ifanydamageorotherdefectsaredetected

during inspection.

Cleaning

Note:Correctcleaningisessentialtoensureintegrityofallsafetyequipment.Followthecleaning

instructions below without deviation.

• Cleanthekarabinerbywipingitwithasoft,lightlyoiledcloth

• Ifthisisnotsufcient,usewarmwaterwithamildpHneutral(pH7)detergent,tocleanoffany

foreignmatter.Drythoroughlyandlubricatemovingpartswithasuitablespraylubricant

• DONOTunderanycircumstancesuseanyabrasivematerials,acids,basicdetergentsorsolvents

• Disinfect parts that come into contact with the operator’s skin, using a disinfectant suitable for

thematerialoftheequipment(see‘Specication’).Strictlyfollowthedisinfectantmanufacturer’s

recommendations and procedures

• ALWAYSallowtheequipmenttodrynaturally,keepitawayfromopenreoranyotherheat

source

Note: This also applies to equipment that has become wet during use.

Lubrication

• Occasionallyapplyasmallamountofasuitablespraylubricant,tothegatemechanism.

Afterwards,performathoroughinspectionasdescribedin‘Inspectionprocedure’

Transport

• ALWAYStransportthisequipmentinsideadedicatedbagorsuitablecontainerthatprotectsit

frommechanicaldamageandshieldstheequipmentfromhightemperatures,humidity,UVrays

and chemicals

Storage

• Storethistoolcarefullyinasecure,dryplaceoutofthereachofchildren

• Storeatmoderatetemperatureandhumidity,awayfromdirectsunlightorchemicals,insidea

dedicated, UV-proof bag or container

• Neverplaceheavyobjectsontopofthisequipment

Disposal

Service life and product obsolescence

WARNING: FallarrestequipmentisdesignedtoarrestafallfromheightONLYONCE!If

subjected to an arrested fall, the equipment must be withdrawn from service and rendered

unusable.

Note:Thedateonwhichtheproductisremovedfromtheoriginalpackagingforthersttime

becomesthe‘dateofrstuse’,whichshouldberecordedontheInspectionRecord(seeendofthis

manual).Thespeciedworkinglifebeginsfromthispoint.

• Thisequipmentissubjecttoamaximumworkinglifeof5yearsfromtherecordeddateof

rstuse,providedtheproducthasbeencorrectlystored,maintainedandsubjectedtoregular

inspectionsbyatrainedandcompetentperson

• Newequipmentmaybestoredforamaximumof5yearsfromthedateofmanufacturingas

indicatedontheproduct,andwillstillgivethepotential5-yearworkinglife-provideditremains

in the original manufacturer's packaging

Note:Otherreasonswhytheproductmaybeconsideredobsoleteincludebutarenotlimitedto

changes of applicable standard, regulations or legislation, development of new techniques or

incompatibilitywithotherequipment.

571429_Manaul.indd 7 10/10/2018 15:04

123456789101112131415161718192021222324252627282930313233343536373839404142434445464748/ 48

Bekijk gratis de handleiding van Silverline 571429, stel vragen en lees de antwoorden op veelvoorkomende problemen, of gebruik onze assistent om sneller informatie in de handleiding te vinden of uitleg te krijgen over specifieke functies.

Productinformatie

Andere merken in Niet gecategoriseerd